Monitoring of ammonia concentrations from coir-husk litter of Brazilian poultry house using diode laser photoacoustic spectroscopy.

Abstract

Ammonia (NH_3) from manure is a concern in raising broiler due to possible damages to production and the environment. Brazil is the main exporter of chicken meat in the world and is also responsible for large waste of poultry litter. The country, likewise, figures as top 5 producers of green coconut, which results in considerable volumes of waste, since 80%-85% of the fruit is unusable. This work analyzes the ammonia concentration profile of two bedding substrates for raising broiler, to know, coir-husk fiber and a commonly used pine wood shavings in a Brazilian climate. A differential home-made photoacoustic cell combined with a diode laser was employed for sensing ammonia at trace levels. Such combination confers selectivity as well as lower limits of detection to the system. The chemical compositions pH, N, C, Ca, Mg, P_2O_5 and K_2O were also determined, in addition to the moisture, dry matter and mineral content of substrates and litters. NH_3 concentrations varied from (0.9 ± 0.3) ppmv to (19 ± 3) ppmv and from (2.1 ± 0.5) ppmv to (21 ± 3) ppmv for the coir-husk fiber and wood shavings substrates, respectively. Results showed the feasibility of using coconut fiber as poultry litter in regions where this material is a common waste. Moreover, as NH_3 concentrations were lower for coconut fiber bedding compared to shavings, this coir-husk fiber is a potential residue to guarantee the environmental sustainability by Brazilian poultry farming. Coir-husk fibers presented significantly higher amounts of P and K in comparison to pine wood. NH_3 profiles revealed that coir-husk fiber emitted lower quantities than wood shavings. Besides, a delay on the NH_3 emission pattern was clearly seen when the coconut waste was the bedding material. Such a tendency was confirmed by the logistic model. Our findings, in turn, make the coir-husk an environmentally friendly alternative low-cost product for poultry litter as well as its potential use as natural fertilizer. The later deserves attention since there is a need to accurately assess the emissions of methane, nitrous oxide, and carbon dioxide during the composting process. In Brazil, the waste generated by the high production of green coconut is an environmental liability. The cost of poultry production has been high, reducing the profit of producers, who seek to make production cheaper. Measuring NH_3 from poultry activity in Brazil, a tropical country, aims to control management and reduce production losses, since NH_3 is a harmful gas to birds. The measurement of NH_3 concentrations at trace levels from raising broilers by photoacoustic diode laser spectroscopy, to the best of our knowledge, has been reported for the very first time.