Modifying physicochemical properties, rheology, and creaming stability of milk fat globule and membrane through ultrasound treatment

Abstract

The healthy benefits of milk fat globules and membrane (MFGs/MFGM) ingredients are increasingly recognized in the dairy industry. In this research, we examined the effects of ultrasonic treatment on the physicochemical and rheological properties, as well as the emulsions stability of MFGs/MFGM derived from bovine raw milk. Fresh milk was subjected to sonication at frequencies of 20 kHz and 40 kHz, either individually or simultaneously, for durations of 5 min or 15 min, using work/rest cycles of 5 s on and 3 s off. Bovine milk, without any treatment, served as the control. Regardless of the intensity difference, ultrasonic treatment for 5 min resulted in more pronounced changes in the regions of Amide Ⅱ (1600–1500 cm−1), Amide Ⅲ (1500–1200 cm−1), and fingerprint region (1200–1900 cm−1) compared to both the 15 min treatments and control MFGs/MFGM. Principal component analysis (PCA) conducted on the entire spectra, as well as in the regions of Amide Ⅰ, Amide Ⅱ, and the fingerprint spectra, clustered the 5 min treatment distinctly from the control and MFGs/MFGM ultrasonically treated for 15 min. MFGs/MFGM samples following 20 kHz and 40 kHz synchronous treatment for 15 min exhibited lower absorbance bands at 1727–1726 cm−1, whereas a higher content at 1740 cm−1 was observed compared to control MFGs/MFGM. Additionally, a more significant reduction in the intramolecular β-sheet content in 20 + 40 kHz/ 15 min treatment was observed. According to the sodium dodecyl sulphate polyacrylamide gel electrophoresis (SDS-PAGE) patterns, a diminished intensity of Periodic Acid Schiff 6/7 (PAS 6/7) bands was observed across all the MFGs/MFGM. Ultrasonic treatment retained more caseins while reducing the β –LG levels compared to the controls, enhancing the stability of MFGs/MFGM, except in MFGs/ MFGM subjected to 20 and 40 kHz simultaneously treated for 15 min. The irregular sphericity of fat globules was noted particularly in MFGs/MFGM treated at 20 kHz independently or in combination with 40 kHz for 15 min. According to the confocal laser scanning microscopy (CLSM), ultrasonic treatment facilitated the binding of caseins or whey proteins to the MFGs surface and induced flocculation of membrane proteins. Hierarchical cluster analysis (HCA) heat map further underscored the impact of ultrasonic treatments on the structural and compositional changes, as well as rheology and emulsions stability, of MFGs/MFGM.