Microstructural modification of papaya tissue during calcium diffusion: Effects on macrostructure level

Abstract

The microstructural changes in papaya tissue during calcium diffusion, the effect on drying kinetics and texture parameters were investigated. Calcium pretreatment was applied to papaya samples for 3 h, at a solution concentration of 1.5 g Ca(OH)2/100 mL H2O, and a solution temperature of 25 °C; subsequently, the samples were convectively dried at 70 °C, air flow of 1.5 m/s, and a relative humidity of 5 ± 2%. Calcium content was determined using the Inductively Coupled Plasma-Optical Emission Spectrometry (ICP-OES) technique, the microstructure of the samples was analyzed by High-Resolution Scanning Electron Microscopy (HR-SEM), and the elementary analysis was performed by Energy-Dispersive X-ray Spectroscopy (EDS). Effective diffusivity of calcium (DefCa) and moisture (Defw) were calculated during pretreatment and drying, respectively and texture parameters were determined by double compression using a texturometer. The transport mechanism determined during calcium pretreatment was diffusion with a DefCa = 3.10 × 10−10 m2/s. Also, branched calcium microstructures in the cell walls of tissue were observed due to the calcium effect, it was supported by elemental analysis, which showed an increase of calcium in section restructured compared to non-restructured. During drying, Defw = 1.86 × 10−9 m2/s was higher in pretreated compared to non-pretreated samples with Defw = 1.17 × 10−9 m2/s, indicating a higher drying rate and moisture loss. The texture values changed significantly (α ≤ 0.05) due to calcium pretreatment and drying; the calcium microstructures caused higher cohesiveness, springiness, gumminess, and chewiness. Calcium modifies the microstructure and composition of papaya tissue; therefore, drying kinetics and texture parameters depend on this modification.