Microbial Community Analysis inside a Biooxidation Heap for Gold Recovery in Equador

Abstract

In a mine owned by the company Orenas S.A. (Equador), a biooxidation process for gold recovery has been developed. Refractory gold ore was crushed, milled and 500 ton of flotation concentrate was agglomerated by coating a support rock. This was piled up on a liner and the biooxidation process in the heap of 35x25x6 m3 was run for approximately 150 days. The oxidized material was subsequently removed for further processing. An outcrop allowed for depth dependent sampling of altogether 36 samples at three sites over the complete depth of 6 m. The fine fraction was removed from the host rock and sent to the laboratory for analysis of the microbial community. The pH ranged between 2.2 and 2.9. Total cell counts determined via counting under a fluorescence microscope after SYBR Green staining indicated a high microbial colonialization of the heap in all depths between 106 to 109 cells per g concentrate, however the highest cell numbers were mainly found in the upper 50 cm. Most-probable-number determination of living, acidophilic iron (II)-oxidizers for one site also revealed a decrease of cell numbers with depth (between 104 to 108 cells per g concentrate). Further molecular analyses of the community composition based on extracted DNA and 16S rRNA gene analyses by TRFLP and qPCR revealed a complex archaeal and bacterial community within the heap. It can be stated that an active community of acidophiles runs the biooxidation process in all sampled parts of the heap.