Mechanical strength of antibiotic-loaded PMMA spacers in two-stage revision surgery

Abstract

BackgroundAntibiotic-loaded polymethylmethacrylate (PMMA) bone cement spacers provide high local antibiotic concentrations and patient mobility during the interim period of two-stage revision for periprosthetic joint infection (PJI). This study compares mechanical characteristics of six dual antibiotic-loaded bone cement (dALBC) preparations made from three different PMMA bone cements. The study`s main objective was to determine the effect of time and antibiotic concentration on mechanical strength of dALBCs frequently used for spacer fabrication in the setting of two-stage revision for PJI.MethodsA total of 84 dual antibiotic-loaded bone cement specimens made of either Copal spacem, Copal G + V or Palacos R + G were fabricated. Each specimen contained 0.5 g of gentamicin and either 2 g (low concentration) or 4 g (high concentration) of vancomycin powder per 40 g bone cement. The bending strength was determined at two different timepoints, 24 h and six weeks after spacer fabrication, using the four-point bending test.ResultsPreparations made from Copal G + V showed the highest bending strength after incubation for 24 h with a mean of 57.6 ± 1.2 MPa (low concentration) and 50.4 ± 4.4 MPa (high concentration). After incubation for six weeks the bending strength had decreased in all six preparations and Palacos R + G showed the highest bending strength in the high concentration group (39.4 ± 1.6 MPa). All low concentration preparations showed superior mechanical strength compared to their high concentration (4 g of vancomycin) counterpart. This difference was statistically significant for Copal spacem and Copal G + V (both p < 0.001), but not for Palacos R + G (p = 0.09).ConclusionsThis study suggests that mechanical strength of antibiotic-loaded PMMA bone cement critically decreases even over the short time period of six weeks, which is the recommended interim period in the setting of two-stage revision. This potentially results in an increased risk for PMMA spacer fracture at the end of the interim period and especially in patients with prolonged interim periods. Finally, we conclude that intraoperative addition of 4 g of vancomycin powder per 40 g of gentamicin-premixed Palacos R + G (Group D) is mechanically the preparation of choice if a dual antibiotic-loaded bone cement spacer with high antibiotic concentrations and good stability is warranted. In any case the written and signed informed consent including the off-label use of custom-made antibiotic-loaded PMMA bone cement spacers must be obtained before surgery.