Low IFT gas–oil gravity drainage in fractured carbonate porous media

Abstract

This paper addresses a study of gas–oil gravity drainage in fractured carbonate rock subjected to gas injection in low interfacial tension. The purpose of the experiments described in the paper was to investigate gas injection in fractured carbonate reservoirs in both secondary and tertiary cases (after water injection), focusing on gravity drainage using equilibrium gas followed by re-pressurization. Gas injection experiments were performed on 20 cm long and low permeable outcrop chalk core surrounded with a fracture established with a novel experimental set-up in reservoir conditions. The core was saturated with binary mixture live oil consisting of C 1 and C 7 of a known composition, while the fracture was filled with sealing material to obtain a homogeneous saturation. After core initialization, the sealing material was removed by increasing the temperature to higher than its melting point and displaced by live oil. Gas was then injected into the fracture and gravity drainage experiments were performed in low interfacial tension (< 0.5 mN/m) where the IFT between the phases were measured experimentally by selecting the proper pressure and temperature. Experiments were performed at different pressures and reversibility of the effect of the interfacial tension was checked by re-pressurization process. The oil recovered from the bottom side of the block was measured versus time. Based on the results of this study, the recovery of oil showed a significant increase by re-pressurization in gravity drainage process. It was also clear that low IFT gravity drainage is capable to recover a significant amount of oil in fractured reservoirs even after water injection.