Abstract
AbstractExamples of monomeric glycerol‐derived hyperbranched polyesters produced in a nonpolar solvent system are reported here. The polymers were made by the Lewis acid [dibutyltin(IV) oxide]‐catalyzed polycondensation of glycerol with either succinic acid [n (aliphatic chain length) = 2], glutaric acid (n = 3), or azelaic acid (n = 7) in toluene. Poly(glycerol–diacid)s were recovered in yields as low as 65% and as high as 95%. The polyesters were characterized by gas chromatography to determine the extent of reaction and by gel permeation chromatography to determine molecular weight, polydispersity index, and degree of polymerization. None of the conditions explored gave 100% conversion but products could be recovered in greater than 97.8% purity. Gelation and low conversion were observed, respectively, for 24‐ and 10‐h polyesterifications of glutaric acid and glycerol (2:1 molar ratio) performed at 155 °C when the standard (neat) synthetic protocol was employed. Gelation was avoided and conversion improved when esterifications were performed in quasi‐melt solutions with toluene. The optimal reaction conditions to produce polymers with high conversion and high molecular weight before the onset of gelation were observed for 24‐h esterifications in toluene at 155 °C (2:1 molar ratio of glutaric acid/glycerol) and 135 °C (1:1 molar ratio of reactants). Expanding on the success of those findings, it was determined that gelation could be avoided for each of the three diacids studied. When all other conditions were held constant, in the absence of gelation, degree of polymerization increased with decreasing aliphatic chain length of the diacid.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.