Leaching characteristics of selected South African fly ashes: Effect of pH on the release of major and trace species

Abstract

Fly ash samples from two South African coal-fired power stations were subjected to different leaching tests under alkaline and acidic conditions in an attempt to assess the effect of pH on the leachability of species from the fly ashes and also assess the potential impact of the fly ashes disposal on groundwater and the receiving environment. To achieve this, German Standard leaching (DIN-S4) and Acid Neutralization Capacity (ANC) tests were employed. Mineralogical characterization of the fresh fly ashes revealed mullite and quartz as the major mineral phases with minor peaks of CaO and calcite. Chemical characterization by X-ray fluorescence (XRF) spectrometry revealed that the two fly ashes are similar, and consist of SiO2, Al2O3, Fe2O3 and CaO as the main components with Cr, Co, Ni, Cu, Zn, V and Pb as minor components. Ca, Mg, Na, K and SO4 were significantly leached into solution under the two leaching conditions with the total amounts in ANC leachates higher than that of DIN-S4. This indicates that a large fraction of the soluble salts in unweathered fly ash are easily leached. These species represents the fraction that can be flushed off initially from the surface of ash particles on contacting the ash with water. Al and Si were only observed in the leachates of the ANC test. Results obtained from the total acid-digestion and DIN-S4 leaching test indicated some toxic elements in the fly ashes are not easily solubilized. The amounts of toxic trace elements such as As, Se, Cd, Cr and Pb leached out of the fly ashes when in contact with de-mineralized water (DIN-S4 test) were low and below the Target Water Quality Range (TWQR) of South Africa. This is explained by their low concentrations in the fly ashes and their solubility dependence on the pH of the leaching solution. However the amounts of some minor elements such as B, Mn, Fe, As and Se leached out at lower pH ranging between 10 to 4 (ANC test) were slightly higher than the TWQR, an indication that the pH of the leaching solution plays a significant role on the leaching of species in fly ash. The high concentrations of the toxic elements released from the fly ashes at lower pH gives an indication that the disposal of the fly ash could have adverse effects on the receiving environment if the pH of the solution contacting the ashes is not properly monitored. The study indicated that on contact with water in a disposal scenario fly ash will release high amounts of soluble species.