Laundry wastewater treatment using coagulation and membrane filtration

Abstract

This paper presents the results obtained from laundry wastewater treatment using conventional methods namely precipitation/coagulation and the flocculation process with adsorption on granular-activated carbon (GAC) and an alternative method, membrane filtrations, namely ultrafiltration (UF) and reverse osmosis (RO). Chemical analyses showed that parameter values of untreated wastewater like temperature, pH, sediment substances, total nitrogen and phosphorous, COD, BOD 5, and the amount of anion surfactants had been exceeded in regard to Slovenian regulation. These regulations can be used as requirements for wastewater reuse and make treated wastewater an available source for the existing water supply. The study of conventional treatment was based on a flocculation with Al 2(SO 4) 3·18H 2O and adsorption on GAC. Membrane filtrations were studied on a pilot wastewater treatment plant: ultrafiltration (UF) and reverse osmosis (RO) units. The membranes used in this experiment were ceramic UF membrane and spiral wounded – polyethersulfone – RO membranes. The quality of the wastewater was improved by both methods and the specifications of a concentration limit for emission into water were confirmed. The disadvantage of GAC is that there is no possibility of any kind of selection, which is essential for recycling and re-use, while permeate coming from RO met the required regulation as well as requirements for reusing in washing process. However, the economical analyses showed that the membrane filtrations are more expensive compared to the GAC treatment process.