Investigations into the Ability to Reduce Cinnamic Acid as Undesired Precursor of Toxicologically Relevant Styrene in Wort by Different Barley to Wheat Ratios (Grain Bill) during Mashing.

Abstract

Styrene is a food-borne toxicant in wheat beer and due to its classification as possibly carcinogenic to humans by the International Agency for Research on Cancer in 2002, mitigation strategies had to be developed. Aiming at understanding the impact of the barley to wheat malt ratio (grain bill) during mashing on the contents of soluble and free (i) cinnamic, (ii) p-coumaric, and (iii) ferulic acid, precursors of (i) styrene and the desired vinyl aromatics (ii) 4-vinylphenol and (iii) 2-methoxy-4-vinylphenol in wheat beer, wort was prepared at four different barley to wheat malt ratios of 100:0, 25:75, 50:50, and 0:100 (w/w). Additionally, the malts were produced at different germination temperatures and aeration rates (12/32, 18/35, 18/25, 24/18, and 26/25 (°C; L/min)) to consider these two further parameters as well. Thereby, soluble and free phenolic acid contents in wort showed linear correlations to the percentage of wheat in the grain bill, highlighting the absence of synergistic effects when mixing barley and wheat malts. In contrast, the results described the phenolic acid contents as a function of the concentrations in the respective barley and wheat wort, multiplied by their percentage in the grain bill. However, a clear recommendation for favorable barley to wheat malt ratios leading to a decrease of soluble and free cinnamic acid in wort could not be made, as the contents in the present study proved to be highly dependent on the barley and wheat varieties used during mashing and the parameters applied during malting. This was not the case for p-coumaric acid for which a clear decrease of the soluble and free forms was found with increasing wheat malt contents. Differently, the soluble form of ferulic acid increased with an increasing percentage of wheat malt, while the free form decreased. The malting parameters clearly recommended high germination temperatures and low aeration rates when aiming at a reduction of undesired cinnamic acid in wort. Fortunately, soluble and free p-coumaric and ferulic acid contents were only slightly affected, indicating that the formation of the characteristic wheat beer aroma might not suffer when applying these favorable conditions for styrene reduction.