Investigation on the utilization of coal washery rejects by different microbial sources for biogenic methane production

Abstract

High energy consumption and depletion of fossil fuels lead to the introduction of new technologies to produce alternative fuels with fewer emissions of greenhouse gases. The present investigation was focused to utilize the waste coal washery rejects as a substrate to produce biogenic methane under optimum conditions. Experiments were performed to explore the efficiency of non-coal samples (cow dung, distillery anaerobic digester sludge) and coal mines enriched samples in the degradation of coal washery rejects. Further cow dung, distillery anaerobic sludge, and coal washery rejects were taken at various concentrations to develop anaerobic slurry and analysed for its biogas production. The anaerobic slurry which contains 1:1:1 of cow dung, distillery anaerobic sludge, and coal washery rejects produced methane of around 55.7%. The coal enriched samples showed a maximum of 22.6% of methane. Subsequently, the best methane-producing anaerobic non-coal consortiums were compared with coal enriched microbial culture in converting coal washery rejects of 10 g/l to methane. Results revealed that cow dung inoculum and coal mine enriched inoculum source produced the nearly same amount of methane. This study suggested that the selected anaerobic slurries and coal enriched samples can utilize sub-bituminous coal washery rejects in methane production. Thus, these consortiums can be applied in converting a large amount of coal washery rejects into methane thus can lead to the reclamation of the site.