Inulinase and fructooligosaccharide production from carob using Aspergillus niger A42 (ATCC 204447) under solid-state fermentation conditions

Abstract

This study aimed to the production of inulinase and fructooligosaccharides (FOSs) from carob under the solid-state fermentation (SSF) conditions by using Plackett-Burman Design (PBD). Based on the results the maximum inulinase and specific inulinase activities were 249.98 U/mL and 318.29 U/mg protein, respectively. When the fructooligosaccharide (FOS) results were evaluated, the maximum values of 1,1,1-Kestopentaose, 1,1-Kestotetraose, and 1-Kestose were 182.01, 506.16, 132.16 ppm while the lowest and highest total FOS values were 179.35 and 516.66 ppm, respectively. On the other hand, it was observed that the maximum inulinase activity was found at the center points of the design. Therefore, validation fermentations were carried out at center point conditions. Subsequently, the yielded bulk enzyme extracts were partially purified using Spin-X UF membranes with 10, 30, and 50 kDa cut-off values. After purification, the maximum inulinase activity was 247.30 U/mg using a 50 kDa cut-off value. Followed by this process, the purified enzyme was used to produce FOSs and the results indicated that the maximum total FOS amount was 28,712.70 ppm. Consequently, this study successfully demonstrates that Aspergillus niger A42 inulinase produced from carob under the SSF conditions can be used in FOSs production.