Inoculation of potato tubers withErwinia carotovora during simulated commercial washing and fluming practices

Abstract

The potential for bacterial soft rot in potato tubers was affected by laboratory simulation of some components of fluming and washing practices at commercial packinghouses. The potential was expressed as disease severity (average percentage surface decayed) after a standard 4-day incubation at 20°C in a mist chamber. Increased disease resulted when there was an increase in the following factors: a) duration of immersion of tubers in water; b) population of bacteria suspended in water; c) hydrostatic pressure on submerged tubers, and d) concentration of a surfactant (Triton X-100) in the suspensions. A sample of tubers from each tuber lot was uniformly moistened with tap water and then incubated to determine a base-level disease severity. Disease severity in Russet Burbank tubers from commercial storage increased from the base-level of 0.8% to 76% when tubers were immersed in 5 × 106 colony-forming units (cfu)/ml ofErwinia carotovora pv.carotovora (Ecc) for 64 min prior to incubation. Disease severity was 64% when tubers were immersed in a similar suspension for only 0.1 min, but with a hydrostatic pressure of 230 cm of water. Severity values fourto fivefold above control levels (from immersion in water) resulted from an immersion for 5 min in 5 × 103 cfu/ml with hydrostatic pressures of 5, 180, or 370 cm of water. A 20-fold increase in severity occurred when Red LaSoda tubers were immersed briefly (less than 5 s) in 5 × 106 cfu/ml. Rinsing these tubers with tap water after inoculation, but prior to incubation, did not affect the subsequent development of decay. Thus, the high potential for bacterial soft rot in tubers that have been flumed or washed by water concentrated with soft rotErwinia cannot be reduced by washes or rinses with clean water.