Inhibitory effects of organic acid salts on growth of Clostridium perfringens from spore inocula during chilling of marinated ground turkey breast

Abstract

Inhibition of Clostridium perfringens germination and outgrowth by salts of organic acids such as sodium lactate, sodium acetate, buffered sodium citrate and buffered sodium citrate supplemented with sodium diacetate was evaluated during continuous chilling of ground turkey. Turkey breast meat was injected with a brine-containing NaCl, potato starch and potassium tetra pyrophosphate to yield final in-product concentrations of 0.85%, 0.25% and 0.20%, respectively. The meat was ground, mixed with either sodium lactate (1%, 2%, 3% or 4%), sodium acetate (1% or 2%), buffered sodium citrate (Ional™, 1%) or buffered sodium citrate supplemented with sodium diacetate (Ional Plus™, 1%), in addition to a control that did not contain added antimicrobials. Each product was mixed with a three-strain C. perfringens spore cocktail to obtain final spore concentrations of ca. 2.8 log 10 spores/g. Inoculated products (10 g) were packaged into cook-in-bags (2×3 in.), vacuum sealed, cooked at 60 °C for 1 h, and subsequently chilled from 54.4 to 7.2 °C in 15, 18 and 21 h following exponential chilling rates. Products were sampled immediately after cooking and then after chilling. Chilling of cooked turkey following 15, 18 and 21 h chill rates resulted in germination and outgrowth of C. perfringens spores to 6.6, 7.58 and 7.95 log 10 CFU/g populations, respectively, from initial spore populations of ca. 2.80 log 10 CFU/g. Incorporation of sodium lactate (1%), sodium acetate (1%), Ional or Ional Plus (1%) substantially inhibited germination and outgrowth of C. perfringens spores compared to controls. Final C. perfringens total populations of 3.12, 3.10, 2.38 and 2.92 log 10 CFU/g, respectively, were observed following a 15-h exponential chill rate. Similar inhibitory effects were observed for 18 and 21 chill rates with the antimicrobials at 1% concentrations. While sodium lactate and sodium acetate concentrations of 1% were sufficient to control C. perfringens germination and outgrowth (<1.0 log 10 CFU/g growth) following 15 h chill rates, higher concentrations were required for 18 and 21 h chill rates. Ional at 1% concentration was effective in inhibiting germination and outgrowth to <1.0 log 10 CFU/g of C. perfringens for all three chill rates (15, 18 and 21 h) tested. Use of sodium salts of organic acids in formulation of ready-to-eat meat products can reduce the risk of C. perfringens spore germination and outgrowth during chilling.