Influence of step-down pressure on wettability-controlled heterogeneous bubble nucleation of sparingly soluble gases in water

Abstract

The liberation of dissolved gas from a liquid typically occurs either by diffusion through the gas–liquid interface and/or by bubble nucleation at the solid–liquid interface. The goal of this research was to study the influences of step-down pressure (degree of supersaturation) and wettability on the onset pressure for bubble nucleation of sparingly soluble gases, methane and nitrogen, in water. Bubble nucleation experiments were carried out with the gas-supersaturated liquids in the hydrophilic (untreated) and hydrophobic (treated) glass vials. The gas-saturated liquids were prepared by saturating water with methane or nitrogen in a glass vial placed in a pressure cell at 6,000 mbar for a minimum of 16 or 15 h, respectively. To initiate the pressure-driven bubble nucleation process, 100-, 500-, or 6,000-mbar step-down pressures were applied to the pressure cell until the bubble nucleation was initiated. Bubble nucleation did not occur in the hydrophilic vial with any of the gas-supersaturated waters, irrespective of the step-down pressures. Unexpectedly, 100-mbar step-down pressure did not cause neither methane nor nitrogen bubble nucleation in the hydrophobic vials. Whereas, both methane and nitrogen bubble nucleations occurred in the hydrophobic vials when the step-down pressure was increased to 500 mbar. The above experimental findings revealed the importance of step-down pressure and surface wetting nature on sparingly soluble gas bubble nucleation. To further understand the experimental findings, an analytical method was developed to estimate the effective supersaturations using Fick’s 2nd law of diffusion and Henry’ law, which indicated that at any given pressure the 500-mbar step-down pressure creates higher supersaturation compared to 100-mbar step-down pressure.