Increasing the dosing of a Buttiauxella phytase improves phytate degradation, mineral, energy, and amino acid digestibility in weaned pigs fed a complex diet based on wheat, corn, soybean meal, barley, and rapeseed meal1.

Abstract

ABSTRACTThis study evaluated the effects of increasing the dose of a 6-phytase from Buttiauxella on phytate degradation, mineral, energy, and AA digestibility in weaned pigs fed complex diets based on wheat, corn, soybean meal, barley, and rapeseed meal. A negative control (NC) diet containing no added inorganic phosphorus (P) and a reduction of 0.1% calcium (Ca) and 36 kcal/kg ME was supplemented with Buttiauxella phytase at 0, 250, 500, 1,000, or 2,000 FTU/kg diet and tested against a nutritionally adequate, positive control (PC) diet. One phytase units (FTU) is the amount of enzyme that liberates 1 micromole of inorganic phosphate per minute from a sodium phytate substrate at pH 5.5 and 37 °C. Barrows (Topigs × Pietrian; initial mean body weight 19.3 kg) were housed individually in metabolic crates and fed the test diets in mash form via 2 equal meals per day for 9 d (fed at 2.5 times the maintenance energy requirement), with 8 replicate pigs per treatment, in 2 experimental runs (total n = 48). After a 3-d adaptation period, urine and feces were collected over 5 d for measurements of apparent total tract digestibility (ATTD) and retention of nutrients. On day 9, pigs were euthanized and ileal digesta collected for measurements of apparent ileal digestibility (AID) of nutrients. Phytase improved (P < 0.05) digestibility of all measured AA except Trp (P < 0.1), and AID P, nitrogen, phytate, ATTD P, Ca versus NC. Increasing phytase dose from 0 (NC) to 2,000 FTU/kg increased AID Lys, Cys, Thr, Val, Ile, Leu, mean AA, P, N, phytate, ATTD P, N, Na, energy, ME, P retention (g/d), and reduced P excretion (g/d) in a linear or exponential manner (P < 0.05). Phytase at 2,000 FTU/kg improved AA digestibility by between +3.1 percentage points (Trp) and +8.8 percentage points (Cys) versus NC (average +6.3 percentage points) (P < 0.05). Phytase inclusion at 2,000 FTU/kg reduced P excretion (g/d) by 57% versus PC (P < 0.05). In conclusion, increasing Buttiauxella phytase in the range of 0 to 2,000 FTU/kg increased phytate degradation, improved AA and P digestibility, and reduced P excretion in weaned pigs fed complex diets.