Inactivation of Salmonella Typhimurium and Staphylococcus aureus by pulsed electric fields in liquid whole egg

Abstract

Abstract In this study, the lethal effectiveness of pulsed electric fields (PEF) on the inactivation of Salmonella enterica subs. enterica ser. Typhimurium and Staphylococcus aureus in liquid whole egg (LWE) has been investigated. Maximum inactivation levels of 4 and 3 Log 10 cycles of the population of Salmonella Typhimurium and S. aureus were achieved with treatments of 45 kV/cm, 30 μs and 419 kJ/kg, and 40 kV/cm for 15 μs and 166 kJ/kg, respectively. The non-linear kinetics of inactivation observed for both microorganisms at all the investigated electric field strengths were described by mathematical equations based on the Weibull distribution. The developed equations enabled to compare the microbial resistance to PEF and to establish the most suitable treatment conditions to achieve a determined level of microbial inactivation. PEF treatments varying from 30 kV/cm, 67 µs and 393 kJ/kg to 45 kV/cm, 19 µs and 285 kJ/kg allow to reduce 3 Log 10 cycles the population of the microorganism of concern in PEF food processing of LWE, Salmonella Typhimurium. Industrial relevance The data presented in this investigation in terms of electric field strength, specific energy and treatment time result of relevance to evaluate the possibilities of PEF technology to pasteurize LWE with this technology. The models developed in this study can be applied to engineering design, and for the evaluation and optimization of the PEF technology as a new technique to obtain Salmonella free LWE. Based on our results it is not recommended to apply treatments of energy levels higher than 250 kJ/kg, since PEF lethality hardly increased but markedly augmented the energetic costs. For these energy values, PEF technology by itself is not sufficient (3 Log10 cycles in the best case scenario) to assure the safe security of LWE. Therefore, intelligent combinations of PEF with other preservation technologies have to be developed in order to use pulsed electric fields as an alternative to heat pasteurization of LWE.