Impact of tillage and mulch management on economics, energy requirement and crop performance in maize–wheat rotation in rainfed subhumid inceptisols, India

Abstract

Different tillage systems (conventional, minimum, raised bed and no tillage) and four mulch levels (control, polythene, straw and soil) were compared in maize (Z ea mays) and wheat (T riticum aestivum) production for three years on an experimental field (sandy loam) located at Dry Land Research Sub Station, Dhiansar, Jammu. Each treatment was replicated four times in split plot design. The aim of the research was to determine the influence of tillage and mulch practices on economics, energy requirement, soil physical properties and performance of maize and wheat. Tillage methods significantly affected the soil physical properties as change in soil moisture contents and infiltration rate of soil was recorded. The soil moisture contents in minimum tillage (MT) were maximum (12.4%, 16.6%) in surface soil as compared to conventional tillage (CT) in maize and wheat crops, respectively. Comparing to the CT infiltration rate was (1.16times, 1.21times and 1.11times) higher in minimum tillage (MT), no tillage (NT) and raised bed (RB), respectively in kharif season. Similar results were also found in rabi season. The greatest maize yield of 1865 kg ha −1 was achieved with CT system while not significantly lower yield was achieved with MT system (1837 kg ha −1). However, wheat yield was recorded higher in MT as compare to the CT system. Comparing to the energy requirement of different operations, MT required 34.3% less, NT 31.1% less and RB 46.0% less than the CT system. MT system saved 2.5 times energy in tillage operation compared to the CT system. The economic analysis also revealed that the maximum benefits could be obtained from MT (EUR 202.4 ha −1) followed by RB (EUR 164.2 ha −1) and NT (EUR 158.3 ha −1) and lowest in CT (EUR 149.5 ha −1). Benefit-cost ratio was highest in MT (0.71) and lowest in CT (0.44). Results revealed that mulch significantly affected the soil physical properties and growth of maize. The maximum soil moisture content, infiltration rate and grain yield of maize and wheat recorded higher in mulching practices over no mulch treatment. Polythene mulch and straw mulch were almost equally valuable in maize and wheat sequence. Tillage (minimum) and mulch (polythene and straw) have pronounced effect on soil physical properties (improved infiltration rate and conserve soil water), energy requirement, economics and growth of maize and wheat.