Abstract
Objectives: The present study was prepared to investigate the impact of insect density, adult emergence of Tribolium castaneum on the secretion of Benzoquinones (BQs) consist of methyl-1,4-benzoquinone(MBQ) and Ethyl-1,4-Benzoquinone (EBQ), and accumulation of Aflatoxins (AFs) in wheat flour stored at different periods. Methods: Forty grams of wheat flour were put into small glass jars (8 cm diameter and 12 cm length). Then T. castaneum was put in each jars at rates of 10, 20 and 30 unsexed pairs of insect adult. The jars were covered with muslin cloth and the rubber band was fixed to prevent insects to escape. A glass jar without any insects served as the control. The jars lifted on bench in the laboratory for two, three and four months of storage under laboratory temperature conditions (with average 28 ± 20C and 65±5 R.H). The previous design was replicated three times. At the end of each storage period, the jars containing the flour were sieved thoroughly by 40 wire mesh size to separate the insects. The insects have been counted on the other hand wheat flour was prepared to determine MBQ, EBQ and AFs by HPLC methods. Results: The results indicated the levels of EBQ higher than MBQ in all infested samples at all insect densities (No. of insect pairs). The concentrations of MBQ in wheat flour released by ten adult pairs (10P) with the three storage periods two, three and four months were 10.42 ± 0.56, 22.38 ± 3.67, 27.06 ± 6.71µg/g, respectively. These results increased with insect densities to (30p) were 39.67 ± 0.10, 63.58 ± 2.35 and 106.24 ± 7.4 µg/g after storage periods two, three and four months, respectively. In addition to the concentrations of EBQ with (10P) were 67.45 ± 3.64, 98.0 ± 6.1 204.66 ± 5.8 µg/g with storage periods two, three and four months, respectively. In case (30P) the levels of EBQ were 376.7 ± 0.87, 570.1 ± 2.11 and 1558.66 ± 10.88 (µg/g). The highest concentration of the BQs 1664.90 ± 11.43 (µg/g) released by T. castaneum achieved with the highest adult emergence (1021 insect adult) and the highest insect density (30p) at four months storage period. In general, AFs levels enhanced with a period of storage and insect densities. Conclusion: Levels of the BQs (MBQ and EBQ) increased with an increase of storage periods and insect densities. Therefore, the presence of this insect should be prevented in stored wheat flour reducing AFs contamination is possible by storage for short time and prohibit insects which causes an increase temperature of the flour and moisture, all of which promote production of AFs.
Highlights
The wheat flour is subjected to attack by many flour beetles, including the red flour beetle (Tribolium castaneum)
The concentrations of MBQ in wheat flour released by ten adult pairs (10P) with the three storage periods two, three and four months were 10.42 ± 0.56, 22.38 ± 3.67, 27.06 ± 6.71μg/g, respectively
Levels of the BQs (MBQ and EBQ) increased with an increase of storage periods and insect densities. The presence of this insect should be prevented in stored wheat flour reducing AFs contamination is possible by storage for short time and prohibit insects which causes an increase temperature of the flour and moisture, all of which promote production of AFs
Summary
The wheat flour is subjected to attack by many flour beetles, including the red flour beetle (Tribolium castaneum). The red flour beetle, T. castaneum is a polyphagous, cosmopolitan pest in flour mills and wherever cereal products and other dried foods were processed and/or stored. It is often the most common species in the pest complex attacking stored wheat. The chemical structures of the major components of these beetles secretions have been shown to consist of Methyl-1,4-Benzoquinone(MBQ) and Ethyl-1,4-Benzoquinone (EBQ), together with the carrier alkene 1pentadecene These compounds are hypothesized to function as external defense compounds, killing microbes and deterring predators, and their ability to evolve by natural selection depends on both selection and the genetic vs environmental contribution to phenotypic variation [2, 3]. This work aims to study the effect of density of T. castaneum on the secretion of BQs and accumulation of AFs in wheat flour stored at different periods
Sign-in/Register to view highlights & summary Sign-in/Register to access full text options 
Free) 
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a call
