Abstract
This research utilized a customized laboratory setup to compare the filtration performance and fouling buildup during microfiltration with polymeric membranes of skim milk using 2 diafiltration media: ultrafiltration permeate and ultrapure water. Two filtration modes were evaluated: in stage 1, the diafiltration media was added in a 1:1 ratio, with the collection of permeate continuing until the initial protein concentration was restored. In stage 2, retentates and permeates were recycled to simulate fouling accumulation in a steady-state without altering the retentate composition. Utilizing water as the diafiltration medium resulted in higher flux and lower resistance values compared with using ultrafiltration permeate, irrespective of the filtration mode. The concentration had a significant impact on membrane resistance, with no noticeable time-dependent effect on fouling layer development after 60 min of filtration when the retentate composition remained constant. The protein composition of the permeate and extracted foulants were comparable between the 2 media, with caseins predominating in the fouling layer.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callDisclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
