Granular activated algae for wastewater treatment.

Abstract

The study used activated algae granules for low-strength wastewater treatment in sequential batch mode. Each treatment cycle was conducted within 24 h in a bioreactor exposed to 235 μmol/m²/s light intensity. Wastewater treatment was performed mostly in aerobic conditions, oxygen being provided by microalgae. High removal efficiency of chemical oxygen demand (COD) was achieved (86-98%) in the first hours of the reaction phase, during which the indicator's removal rate was 17.4 ± 3.9 mg O₂/g h; NH(4)(+) was removed during organic matter degradation processes with a rate of 1.8 ± 0.6 mg/g h. After almost complete COD removal, the (O⁺) remaining in the liquor was removed through nitrification processes promoted by the increase of the liquor's oxygen saturation (O₂%), the transformation rate of NH4(+) into NO(3)(-) increasing from 0.14 ± 0.05 to 1.5 ± 0.4 mg NH4(+)/g h, along with an O₂% increase. A wide removal efficiency was achieved in the case of PO(4)(3)(-) (11-85%), with the indicator's removal rate being 1.3 ± 0.7 mg/g h. In the provided optimum conditions, the occurrence of the denitrifying activity was also noticed. A large pH variation was registered (5-8.5) during treatment cycles. The granular activated algae system proved to be a promising alternative for wastewater treatment as it also sustains cost-efficient microalgae harvesting, with microalgae recovery efficiency ranging between 99.85 and 99.99% after granules settling with a velocity of 19 ± 3.6 m/h.