Fluid flow and heat transfer of natural convection around large horizontal cylinders: Experiments with air

Abstract

AbstractNatural convective flows of air around large horizontal cylinders were investigated experimentally. The main concerns were the turbulent transition mechanisms and the heat transfer characteristics of turbulent flows. The cylinders were heated with uniform heat flux and their diameters were varied from 200 to 1200 mm to enable experiments over a wide range of modified Rayleigh numbers, RaD* = 1.0 × 108 to 5.5 × 1011. The flow fields around the cylinders were visualized with smoke to investigate the turbulent transition mechanisms. The results show that three‐dimensional flow separations occur first at the trailing edge of the cylinder when RaD* exceeds 3.5 × 109, and the separation points shift upstream with increasing Rayleigh numbers. These separations become a trigger to the turbulent transition and transitional and turbulent flows appear downstream of the separations at higher Rayleigh numbers. However, they occupy a relatively small portion of the cylinder surfaces even at the maximum Rayleigh numbers of the present experiments. The local heat transfer coefficients were also measured. The results show that the coefficients are increased significantly in the transitional and turbulent regions compared with the laminar coefficients. Moreover, the present results for air were compared with previous results for water and the effects of Prandtl number on the flow and heat transfer were discussed. © 2003 Wiley Periodicals, Inc. Heat Trans Asian Res, 32(4): 293–305, 2003; Published online in Wiley InterScience (www.interscience.wiley.com). DOI 10.1002/htj.10080