Abstract
As a very promising thermochromic material, VO2 (M/R) (Monoclinic/Rutile) has not been widely applied in smart windows due to its intrinsic low solar modulation (ΔTsol) and low luminous transmission (Tlum). To address this issue, porous structures have been introduced into the VO2 film. Herein, mesoporous VO2 powders with pore size of about 2–10nm were synthesized using cotton as template by hydrothermal methods. The pore and crystal size of the synthesized VO2 powders can be reliably controlled by the hydrothermal temperature. The mesoporous VO2 powders were mixed with PVP to prepare the VO2-based nanocomposite films by spin coating. The VO2-based films show a better performance between ΔTsol and Tlum than that appeared in previous reports. Especially, a larger pore size could lead to a higher visible transmittance and a larger crystal size would facilitate the enhancement in the solar modulation. In this sense, the VO2-based film obtained at the hydrothermal temperature of 180°C exhibits an outstanding thermochromic performance with ΔTsol of 12.9% and Tlum up to 56.0% due to a larger crystal size and pore size. Therefore, this synthetic route shows a potential method for the application of mesoporous VO2 powders for solar control coatings.
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Disclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.