Experiments in free falling and downward cocurrent annular flows – Characterization of liquid films and interfacial waves

Abstract

Falling liquid films and downward cocurrent flows in rounded shape pipes have been experimentally studied during the last decades, estimating the evolution of its major characteristics. The most important variables during the formation and growth of surface waves in falling downward flows have been measured using conductance probes.The main objective of the current research paper is to study the dependency of the characteristics of the thin liquid layer for downward cocurrent annular flows. The GEPELON experimental facility consists of a vertical pipe with 3.8 m of useful test length. Two pipe diameters have been analysed in this experimental study, 42 and 30 mm, in which the range covered by the liquid Reynolds number varies between 570 and 8500 and 800–7900 respectively, while the gas Reynolds numbers vary from 0 to 7.9·104 and from 0 to 1.1·105 respectively for the mentioned pipe diameters. Up to five conductance probes have been placed along the pipes test sections to capture the liquid film thickness fluctuations along time at different distances of the pipe entrance for both developing and fully developed regions.After the study and analysis of the experimental data, the central point of this paper has been the development of new correlations for the liquid film thicknesses and the two major properties of the interfacial waves. Their adjustment procedure has been carried out in terms of dimensionless numbers, aiming to provide more general relationships. In particular, the magnitudes that characterise the interface behavior have been measured, particularly film thicknesses, average disturbance wave amplitudes, and disturbance wave frequencies for each boundary condition.An additional part of the document contains an extensive comparison between the results obtained in this study and the data and expressions of other authors. It has been confirmed the significant dispersion existing among different researchers, especially when analysing variables related to the interfacial waves. This highlights the lack of knowledge in some aspects even today. The different correlations proposed have been calculated based on the best fit of the data from all the series of experiments carried out in this study. Comparisons of the behaviour of these correlations with data from other researchers have also been included.