Experimental and simulation studies on the improvement of coal dust pollution by an aqueous solution of sodium α-alkenylsulfonate and amino acid-based surfactants

Abstract

The use of surfactants is crucial for the prevention and control of coal dust pollution in coal mining operation areas, yet there still exist many challenges in the control of coal dust pollution. In this paper, the green biomass-based amino acid surfactant sodium myristoyl glutamate (SMG) and the anionic surfactant sodium α-alkenyl sulfonate (AOS) were selected to investigate the improvement of coal dust wettability by single and binary solutions from the macroscopic and microscopic perspectives. Molecular simulations were used to reveal the microscopic mechanism of the wettability of coal dust by the different solutions. Experimental measurements showed that the contact angle of the AOS + SMG aqueous solution was as low as 13.8° on a coal surface. Coating the coal dust with the AOS + SMG solution reduced the surface tension by 12.02% compared to coating the coal with a single component solution. Additionally, the use of the binary AOS + SMG solution increased the hydrophilic group content in the coating by 11.77% compared to a single component solution, and the linkage between hydrophilic groups was enhanced, which pulls the water molecules to wet the coal dust. These research results should provide a new way to promote more environmentally friendly coal dust pollution control technology.