Experimental and empirical study of steam condensation heat transfer with a noncondensable gas in a small-diameter vertical tube

Abstract

An experimental study was performed to investigate local condensation heat transfer coefficients in the presence of a noncondensable gas inside a vertical tube. The data obtained from pure steam and steam/nitrogen mixture condensation experiments were compared to study the effects of noncondensable nitrogen gas on the annular film condensation phenomena. The condenser tube had a relatively small inner diameter of 13 mm (about 1/2-in.). The experimental results demonstrated that the local heat transfer coefficients increased as the inlet steam flow rate increased and the inlet nitrogen gas mass fraction decreased. The results obtained using pure steam and a steam/nitrogen mixture with a low inlet nitrogen gas mass fraction were similar. Therefore, the effects of noncondensable gas on steam condensation were weak in small-diameter condenser tubes. A new correlation was developed to evaluate the condensation heat transfer coefficient inside a vertical tube with noncondensable gas, irrespective of the condenser tube diameter. The new correlation proposed herein is capable of predicting heat transfer rates for tube diameters between 1/2- and 2-in. because of the unique approach of accounting for the heat transfer enhancement via an interfacial shear stress factor.