Evaluation of Incise Drape Lift Using 2% Chlorhexidine Gluconate/70% Isopropyl Alcohol Preoperative Skin Preparations in a Human Volunteer Knee Model.

Abstract

BackgroundBefore surgery, skin is prepped with antiseptics to reduce risk of surgical site infections. An incise drape can be used as an additional modality to immobilize any remaining bacteria. Good adhesion of this drape is critical for infection prevention.MethodsThis is a randomized controlled study using a human volunteer knee model (n = 30) to evaluate the adhesion performance of an incise drape comparing 2 skin preparations. A new investigational 2% chlorhexidine gluconate/70% isopropyl alcohol skin prep (prep A) was compared with an existing skin prep containing the same active agents (prep B). Two samples of an iodine-impregnated incise drape were placed on each knee after prepping. Knees were flexed in dry conditions, under a saline-soaked gauze, and after saline lavage. The frequency of drape lift was recorded after each challenge.ResultsAfter dry flex, 4 of 60 samples (6.7%) had lifted on prep A and 0 on prep B (P = .125). After wet flex, 20 of 60 samples (33%) had lifted on prep A, whereas 42 of 60 samples (70%) had lifted on prep B (P < .0001). After lavage, 23 of 60 samples (38%) had lifted on prep A, whereas 48 of 60 samples (80%) had lifted on prep B (P < .0001). Both preps were well tolerated with minimal erythema and no edema, rash, dryness, or denudation observed. No adverse events were reported.ConclusionsPrep A resulted in reduced frequency of incise drape lift from skin under wet conditions in this model compared with prep B.