Enhanced bioremediation of methyl tert-butyl ether (MTBE) by microbial consortia obtained from contaminated aquifer material

Abstract

A microcosm study was carried out to evaluate the potential for biodegradation of methyl tert-butyl ether (MTBE) impacting groundwater at a former oil refinery site located in Naples (SW Italy). A screening of aerobic, anaerobic and co-metabolic aerobic conditions was carried out by triplicate batch reactors, using contaminated soil and groundwater from the study site. All microcosms were amended with ammonium and phosphate salts and, if aerobic, they were supplied with excess oxygen throughout the static incubation period of 6 months. Propane, pentane and n-hexane were selected as the primary substrates for co-metabolic treatments. After the initial lag phase (40–60 d), quantitative MTBE decay was repeatedly observed in the aerobic set amended only with nitrogen and phosphorus and further fed with MTBE, thus suggesting that the indigenous soil bacteria have the ability to degrade MTBE. All other treatments, i.e., anaerobic and co-metabolic aerobic, resulted unsuccessful after incubation extending up to 190 d. Bacterial consortia in the active microcosms were later enriched and further studied through second and third generation batch reactors with no soil, operated under continuous mixing for 5–7 months. MTBE degradation rate progressively increased with reactor operating time, following a zero order kinetics in the concentration range 1–10 mg L −1 and leading to a residual concentration of less than 10 μg L −1. The calculated maximum biodegradation rate was 20 mg MTBE g VSS −1 h −1. An accumulation of nitrite ions also occurred after long operating times, thus inhibiting MTBE degradation. This effect was minimized by replacing ammonium with nitrate. Identified degradation intermediates were tert-butyl alcohol and tert-butyl formate. Fluorescent in situ hybridization was applied for a preliminary microbiological screening of the consortia, suggesting that the detected cocci (about 0.5 and 1.5 μm diameter, respectively) and long bacilli with a narrow diameter might be as yet undescribed species.