Engineering Properties and Microscopic Mechanisms of Composite-Cemented Soil as Backfill of Ultra-Deep and Ultra-Narrow Foundation Trenches

Abstract

The backfilling of lime soil in ultra-deep and ultra-narrow foundation trenches is a difficult construction link, and ordinary-cemented soil has drawbacks, including poor strength, impermeability, and frost resistance. To solve these problems, fly ash (FA)–water glass (WG)-composite-cemented soil is developed based on a background project. The three-factor orthogonal tests are conducted on the unconfined compressive strength (UCS) of the composite-cemented soil, and the optimal engineering mix proportion is proposed for the FA-WG-composite-cemented soil. Its UCS is compared with that of cemented soil only doped with FA or WG (FA- and WG-cemented soil). In addition, the cyclic wetting–drying tests, cyclic freeze–thaw tests, and impermeability tests are carried out to study the endurance of the composite-cemented soil in cold regions rich in water. The hydration products of the composite-cemented soil are investigated through scanning electron microscopy (SEM) and X-ray diffraction (XRD) analysis, and the curing mechanism of the composite-cemented soil is discussed from the microscopic perspective. The research results indicate that the mixing ratio of cement is crucial to the strength development of the cemented soil; the mixing ratio of FA greatly influences the strength development of the cemented soil in the middle and late stages; the mixing ratio of WG only slightly affects the strength. The ratio of cement, FA, and WG of 9%:12%:3% is the optimal engineering mix proportion of the composite-cemented soil. Compared with ordinary-cemented oil and FA- and WG-cemented soil, the composite-cemented soil shows significantly improved compressive load-bearing capacity. The permeability coefficient of the composite-cemented soil is always obviously lower than that of the ordinary-cemented soil after any curing period. Despite the mass loss, the composite-cemented soil is superior to the ordinary one in overall endurance after wetting–drying and freeze–thaw cycles. Through SEM and XRD analysis, the content of hydration products of the composite-cemented soil is found to be obviously higher than that of ordinary-cemented soil after any curing period, and the hydrates exert stronger cementing action on soil particles in the composite-cemented soil. The contents of C-S-H gel and Aft crystals in the composite-cemented soil are apparently larger than those in the ordinary-cemented soil. Under the alkali activation of WG, the FA produces free SiO32− and AlO2−, which undergo the polymerization reaction with Ca2+ to generate C-S-H gel and C-A-H gel, further promoting the hydration of cement.