Abstract
This study evaluated the efficacy of ozone as a fumigant to disinfest stored maize. Treatment of 8.9 tonnes (350 bu) of maize with 50 ppm ozone for 3 d resulted in 92–100% mortality of adult red flour beetle, Tribolium castaneum (Herbst), adult maize weevil, Sitophilus zeamais (Motsch.), and larval Indian meal moth, Plodia interpunctella (Hübner) and reduced by 63% the contamination level of the fungus Aspergillus parasiticus Speare on the kernel surface. Ozone fumigation of maize had two distinct phases. Phase 1 was characterized by rapid degradation of the ozone and slow movement through the grain. In Phase 2, the ozone flowed freely through the grain with little degradation and occurred once the molecular sites responsible for ozone degradation became saturated. The rate of saturation depended on the velocity of the ozone/air stream. The optimum apparent velocity for deep penetration of ozone into the grain mass was 0.03 m/s, a velocity that is achievable in typical storage structures with current fans and motors. At this velocity 85% of the ozone penetrated 2.7 m into the column of grain in 0.8 d during Phase 1 and within 5 d a stable degradation rate of 1 ppm/0.3 m was achieved. Optimum velocity for Phase 2 was 0.02 m/s. At this velocity, 90% of the ozone dose penetrated 2.7 m in less than 0.5 d. These data demonstrate the potential usefulness of using ozone in managing stored maize and possibly other grains.
Published Version
Talk to us
Join us for a 30 min session where you can share your feedback and ask us any queries you have
Schedule a callDisclaimer: All third-party content on this website/platform is and will remain the property of their respective owners and is provided on "as is" basis without any warranties, express or implied. Use of third-party content does not indicate any affiliation, sponsorship with or endorsement by them. Any references to third-party content is to identify the corresponding services and shall be considered fair use under The CopyrightLaw.
