Effects of oxygen supply on yeast growth and metabolism in continuous fermentation

Abstract

The yield changes in cell mass and metabolites with changes in the oxygen supply rate were investigated in continuous ethanol fermentation. With increases in oxygen concentration in the purging gas from 5.3 to 39.3 %, the specific oxygen uptake rate ( qO 2) increased from 0.158 to 1.24 mmol/g/h. With this change, cell mass increased from 13.2 to 14.9 g/ l and glycerol decreased from 4.8 to 0.99 g/ l, although little change in ethanol yield was observed. At a higher oxygen concentration and/or at a lower respiratory quotient (RQ), glycerol disappeared, acetaldehyde, acetoin and 2,3-butanediol increased, and ethanol started to decrease. The yields of iso-butylalcohol and iso-amylalcohol also increased with increases in the oxygen supply rate when RQ was lower than approximately 10. Reduction in the redox balance (NADH/NAD) in the cells by qO 2, appeared to reduce initially the rate of glycerol-3-phosphate formation and next the rate of ethanol formation, resulting in the accumulation of acetaldehyde and formation of 2,3-butanediol through acetoin. Fatty acid composition changed with changes in the oxygen supply rate. The value for unsaturation, Δ mol −1, increased from 0.745 to 0.836 with the increase in qO 2 from 0.158 to 1.79 mmol/g/h. Increases in oleic acid (C18:1) and decreases in palmitic acid (C16:0) were the major changes with the increases in Δ mol −1.