Effects of lidocaine administration via the perforated outer cuff of a dual-cuff endotracheal tube and remifentanil administration on recovery from general anaesthesia for female patients undergoing thyroidectomy: a single centre, double-blind, randomised study

Abstract

BackgroundCough caused by endotracheal tube (ETT) placement is ubiquitous and correlates with adverse outcomes. Remifentanil administration via target-controlled infusion (TCI) is one of the cough prevention measures used during recovery. In a pilot study, lidocaine administered via the perforated outer cuff of a dual-cuff endotracheal tube was also found to prevent cough due to ETT placement. We therefore compared these two cough prevention approaches during recovery after thyroidectomy in a single-centre, double-blind, randomised study conducted in China during the period from 09/10/2020 to 30/04/2021.MethodsNinety-eight female patients aged 18–65 years with American Society of Anaesthesiologists Physical Status scores of I and II were scheduled to undergo thyroidectomy. The ETT contained an internal cuff covered by a perforated outer cuff to allow for lidocaine delivery. Patients were randomised to receive either 4 ml of saline solution (Group R, n = 49) or 4 ml of 2% lidocaine in the outer cuff (Group L, n = 49) at the beginning of skin suturing. Remifentanil (2 ng/ml) was maintained in Group R until extubation, while remifentanil was maintained in Group L until the end of skin suturing. The primary outcome was cough during patient transfer, at 1 min before extubation, and at extubation. The secondary outcomes were haemodynamics and other recovery parameters.ResultsPrimary outcomes were compared between remifentanil vs. lidocaine application, namely, the incidence of cough during patient transfer (0% in Group R vs. 0% in Group L), at 1 min before extubation (22.45% in Group R vs. 4.08% in Group L; P = 0.015), and at extubation (61.22% in Group R vs. 20.41% in Group L; P < 0.001). Compared with remifentanil, lidocaine more effectively decreased heart rate elevation and hypoxemia at 5 min after extubation, the spontaneous respiration recovery time, the extubation time, the duration of post-anaesthesia care unit (PACU) stay, Richmond Agitation-Sedation Scale scores in the agitated range and Critical-Care Pain Observation Tool scores.ConclusionLidocaine administered via the perforated outer cuff of the ETT significantly improved recovery from general anaesthesia compared to remifentanil in female patients after thyroidectomy.Trial registrationChinese Clinical Trial Registry (No. ChiCTR2000038653), registered on 27/09/2020.