Effects of immunological castration and distiller's dried grains with solubles on carcass cutability and commercial bacon slicing yields of barrows slaughtered at two time points.

Abstract

Male pigs were randomly assigned to a castration method at birth and allotted to 48 pens (28 pigs/pen). Physically castrated (PC) barrows were castrated at 2 d of age; immunologically castrated (IC) barrows were administered Improvest (GnRF analog diphtheria toxoid conjugate; Zoetis, Kalamazoo, MI) at 16 and 20 wk of age. Distiller's dried grains with solubles (DDGS) feeding strategies included either 0% DDGS (control), 30% DDGS (30% DDGS) fed from 6 wk of age to slaughter, or 30% DDGS fed from 6 wk of age to second dose of Improvest and then fed 0% DDGS until slaughter (withdrawal). Four barrows closest to the median pen weight at 4.5 wk after second dose were selected for evaluation; two were randomly selected and slaughtered at 5 wk and the other two at 7 wk after second dose. Data from each slaughter time were analyzed independently as a 2 × 3 factorial design with pen as the experimental unit. At 5 wk after second dose, bone-in lean cutting yields were 2.63% units greater (P < 0.01) in IC when compared to PC. Bellies were thicker (P < 0.01) and tended to have greater belly flop distances (P = 0.07) in PC compared to IC, however iodine values (IV) were not altered (P = 0.84). Carcass traits (P ≥ 0.10), cutting yields (P ≥ 0.43), and fresh belly characteristics (P ≥ 0.08) were minimally affected by DDGS feeding strategy. Bacon slicing yields (percentage of green weight) were 6.10% units less (P < 0.01) in IC compared with PC. At 7 wk after second dose, bone-in lean cutting yields were 1.57% units greater (P = 0.03) in IC compared with PC. Distiller's grains feeding strategy had no effect (P ≥ 0.83) on boneless carcass cutting yields in IC; while in PC, these yields were 2.32% units less (P < 0.02) in control-fed barrows when compared to other feeding strategies (castration method × feeding strategy; P = 0.03). Bellies from PC tended to be thicker (P = 0.07) and have similar flop distances (P = 0.44) and IV (P = 0.54) when compared with IC. Iodine value was greater (P = 0.03) in 30% DDGS-fed barrows compared with control-fed barrows. Bacon slicing yields (percentage of green weight) were 4.27% units less (P = 0.05) in IC compared with PC. These data suggested that while bacon slicing yield was reduced in IC barrows fed control and 30% DDGS compared with PC barrow counterparts, withdrawal of DDGS improved bacon slicing yields of IC barrows.