Effects of distillers dried grains with solubles on amino acid digestibility, growth performance, and carcass characteristics of growing pigs.

Abstract

Two experiments were conducted to compare the standardized ileal digestibility (SID) of AA by growing pigs in European distillers dried grains with solubles (DDGS) produced from wheat, maize, or wheat–maize mixtures and to test the effect of increasing the inclusion levels of wheat DDGS on growth performance of growing-finishing pigs fed diets balanced for NE and SID Lys. In Exp. 1, 12 barrows (initial BW: 23.0 ± 2.2 kg) were surgically equipped with a T-cannula in the distal ileum and randomly allotted to a replicated 6 × 6 Latin square design with six diets and six periods. Five sources of European DDGS were used: wheat DDGS from 2011, wheat DDGS from 2012, wheat-80 DDGS (80% wheat and 20% maize), wheat-70 DDGS (70% wheat and 30% maize), and maize DDGS. Each diet contained one source of DDGS as the sole source of AA and an N-free diet was used to determine basal endogenous losses of AA. Results indicated that the SID of CP was greater (P < 0.05) in maize DDGS compared with wheat DDGS from 2011, wheat DDGS from 2012, and wheat-70 DDGS. The SID of all indispensable AA except Trp was also greater (P < 0.05) in maize DDGS compared with all other DDGS sources used in this experiment. For Trp, the SID in wheat-80 DDGS, wheat DDGS from 2011, and wheat DDGS from 2012 were not different from maize DDGS, but were greater (P < 0.05) than in wheat-70 DDGS. The SID for all indispensable AA except Ile and Trp in wheat-70 DDGS were not different from the values calculated for wheat DDGS from 2011 and wheat DDGS from 2012, and no differences between SID values for AA in wheat DDGS from 2011 and wheat DDGS from 2012 were observed. In Exp. 2, 36 growing pigs (initial BW: 38.3 ± 1.97 kg) were randomly allotted to one of four dietary treatments (one pig/pen and nine replicate pigs/treatment) in a 2-phase feeding program (35 to 65, and 35 to 105 kg BW). The four dietary treatments included diets containing 0%, 10%, 20%, or 30% wheat DDGS. Results indicated that there was no effect of wheat DDGS on pig growth performance or carcass quality. However, addition of wheat DDGS increased linearly (P < 0.015) the indole concentration in the carcasses of the pigs. In conclusion, the SID of AA in maize DDGS produced in Europe is greater than in European wheat DDGS and DDGS produced from mixtures of wheat and maize, but inclusion of 30% wheat DDGS in diets fed to growing-finishing pigs did not affect growth performance or carcass quality.