Effectiveness of Ionizing Radiation in Reducing Furan and Acrylamide Levels in Foods

Abstract

Furan and acrylamide are two possible carcinogens commonly found in many thermally processed foods. The possibility of using ionizing radiation to reduce the levels of thermally induced furan and acrylamide in water and selected foods was investigated. Aqueous furan solutions, and foods (frankfurters, sausages, infant sweet potatoes) that contained furan were irradiated to various doses of gamma-rays. Water and oil spiked with acrylamide and potato chips (a known acrylamide-containing food) were also irradiated. In addition, possible irradiation-induced formation of acrylamide in glucose and asparagine solutions was analyzed. Results showed that irradiation at 1.0 kGy destroyed almost all furan in water. In frankfurters, sausages, and infant sweet potatoes, the rate of irradiation-induced destruction of furan was much lower than the rate in water, although significant reductions in furan levels were observed in all foods. Irradiation at 2.5-3.5 kGy, doses that can inactivate 5-log of most common pathogens, reduced furan levels in the food samples by 25-40%. Similarly to furan, acrylamide in water was also sensitive to irradiation. After 1.5 kGy of irradiation, most of the acrylamide was degraded. Irradiation, however, had a very limited effect on acrylamide levels in oil and in potato chips, even at a dose of 10 kGy. No detectable acrylamide was formed in the mixture of asparagine and glucose upon irradiation. These results suggest that a low dose of irradiation easily destroys furan and acrylamide in water. In real foods, however, the reduction of furan was less effective than in water, whereas the reduction in acrylamide was minimal.