Effect of trunk flexion angle and time on lumbar and abdominal muscle activity while wearing a passive back-support exosuit device during simple posture-maintenance tasks

Abstract

Quantifying the trunk flexion angles at which wearable support systems (exoskeletons/exosuits) provide substantial trunk extension moment during posture maintenance tasks (such as those seen in surgical environments) can provide a deeper understanding of this potential intervention strategy. Understanding how time (i.e. adaptation/learning) might impact the reliance on wearable support is also of value. Sixteen participants were asked to maintain specific trunk flexion angles (range 0–60°) with and without an exosuit system while erector spinae and rectus abdominis muscle activity were captured using surface electromyography. The effects of the exosuit showed a statistically significant (p < 0.007) effect on the activity of the erector spinae muscles at 10–60°–an effect that became ‘large’ (Cohen's d = 0.84) after 20° of trunk flexion. There were no meaningful time-dependent trends in the levels of muscle activation indicating there was no adaptation/learning effect of the exosuit in the task studied. Practitioner summary: This study examined the effectiveness of a back-support exosuit as a function of trunk flexion angle and time of use. The results revealed that the exosuit significantly reduced erector spinae muscle activity beyond 20° of trunk flexion but did not show a meaningful adaption/learning effect. Abbreviations: LBP: low back pain; EMG: electromyography; NEMG: normalized electromyography; IMU: inertial measurement unit; ES: erector spinae; RA: rectus abdominis; MVC: maximum voluntary contraction; FFT: Fast Fourier Transform.