Effect of the ammonium salt anion on the structure of doxorubicin complex and PEGylated liposomal doxorubicin nanodrugs

Abstract

BackgroundIn Doxil®, PEGylated nanoliposomes are created by hydration of the lipids in ammonium sulfate, and are remotely loaded with doxorubicin by a transmembrane ammonium gradient. The ammonium sulfate is then removed from the external aqueous phase, surrounding the liposomes, and replaced by an isoosmotic sucrose solution in 10 mM histidine buffer at pH 6.5. MethodsWe prepared PEGylated liposomal doxorubicin (PLD) with a series of ammonium monovalent salts that after remote loading became the intraliposome doxorubicin counteranions. We analyzed the liposomes by solution X-ray scattering, differential scanning calorimetry, and electron micropscopy. ResultsPLDs prepared with sulfonic acid derivatives as counteranion exhibited chemical and physical stabilities. We determined the effect of these ammonium salt counteranions on the structure, morphology, and thermotropic behavior of the PEGylated nanoliposomes, formed before and after doxorubicin loading, and the bulk properties of the doxorubicin-counteranion complexes. By comparing the structure of the doxorubicin complexes in the bulk and inside the nanoliposomes, we revealed the effect of confinement on the structure and doxorubicin release rate for each of the derivatives of the ammonium sulfonic acid counteranions. ConclusionsWe found that the extent and direction of the doxorubicin confinement effect and its release rate were strongly dependent on the type of counteranion. The counteranions, however, neither affected the structure and thermotropic behavior of the liposome membrane, nor the thickness and density of the liposome PEG layers. In an additional study, it was demonstrated that PLD made with ammonium-methane sulfonate exhibit a much lower Hand and Foot syndrome. General significanceThe structure, physical state, and pharmacokinetics of doxorubicin in PEGylated nanoliposomes, prepared by transmembrane remote loading using gradients of ammonium salts, strongly depend on the counteranions.