Effect of Relative Humidity on Water Loss of Strip Loins Dry-Aged in a Highly Moisture Permealbe Bag

Abstract

ObjectivesThe aim of this study was to evaluate the effects of 2 relative humidity RH (65% or 85%) and 2 aging times (21 or 42 d) on water loss of dry-aged strip loins unpackaged or packaged in a highly moisture permeable bag. Materials and MethodsA total of 16 beef loins (8 pairs), from Nellore intact males, were collected at a commercial plant and sent to the meat lab. Each pair was cut in 8 equal parts and used to one of each treatment combination (2 RH: 65% or 85%; 2 aging times: 21 or 42 d; unpackaged and packaged). The aging chambers were set to the desired RH and the temperature was set at 2°C. Samples were deboned and packaged samples were put in dry aging bags (Tublin 10, TUB-EX ApS, Denmark) using vacuum to seal the bags to get contact between the bag and the meat. Samples were weighed and position within the aging chamber was rotated every 3 d. Aging loss (evaporation and trimming), moisture content and surface water activity, were determined. The statistical analysis was performed using a factorial ANOVA, and means (± SEM) were tested by Tukey test at 5% significance. ResultsAt 21 d of aging it was verified the presence of a bad smell and slime on samples aged without bag at 85% of RH. These samples were analyzed, however the same treatment (unpackaged), assigned to 42 d, were discarded. At 65% of RH, a greater evaporation loss (P 0.05). Evaporation loss of packaged samples at 42 d/85% RH was 19.2 ± 0.4%. At 21 d, evaporation loss of samples at 85% RH was lower (P 0.05) by type or time of aging of samples aged at 65% RH. On the other hand, at 21 d/85% RH, non-packaged samples had higher (P 0.05) on packaged samples aged at 85% RH. A lower surface water activity was verified for samples aged at 65% RH, independent of time or type of aging, when compared with samples aged at 85% RH (P 0.05). The increase of aging time decreased water activity of samples aged at 65% RH without bag, as well as for samples aged at 85% RH with bag (P 0.05) on packaged samples aged at 65% RH. ConclusionThe higher relative humidity used in this experiment (85%) was unable to produce a viable dry aged beef, mainly without the use of a permeable bag. The use of an aging bag can increase yield, however the surface water activity is higher, so the microbiological growth needs to be studied.