Effect of puddling intensity on physical properties of a silty clay soil under laboratory and field conditions

Abstract

Conventional tillage and planting method for rice (Oryza sativa L.) production in northern Iran is wet tillage (puddling). Effect of different puddling intensities on physical properties of a silty clay soil (Typic Haplodalfs) was investigated under laboratory and field conditions. Changes in soil physical parameters and water requirement for puddling were measured. For laboratory experiments, undisturbed cylindrical soil samples (diameter and height of 50 cm), were used. A laboratory puddling apparatus was designed and constructed. The puddling intensity was measured by duration of puddling. Four levels of puddling intensity were used as: P0 (no puddling, control), P1 (low), P2 (medium) and P3 (high). For field tests, 12 plots of 8 × 4 m were selected. The first tillage was performed with a moldboard plow and then the plots were puddled with different intensity using a rotary tiller. The results showed that under laboratory conditions, water content of the puddled layers decreased with an increase in settling time. During drying period, P0 dried faster than P1, P2 and P3. Puddling with low intensity in laboratory and field conditions caused bulk density of 0–15 cm soil layer to decrease by 24.07 and 25.45%, respectively. Increasing puddling intensity increased the bulk density. Bulk density increased with time as particles settled after halting the puddling. Bulk density increased with depth as well. Under laboratory conditions, increasing puddling intensity from P1 to P2 reduced percolation rate significantly. For all puddling intensities, soil moisture characteristic curves of both field and laboratory samples showed that puddling increased the amount of water retained over the whole range of suctions. More water was needed for P3 as compared to P1 and P2. Under the laboratory and field conditions, the P3 required 27.72 and 28.58% more water as compared to P2, respectively. Although the mechanisms implemented for puddling were different under laboratory and field experiments, the results were similar. Bulk density, soil moisture content and water percolation rate decreased faster in the puddled soil under field and laboratory conditions. Therefore, to reduce the cost and time, the laboratory method could be used to study the effects of puddling intensity on physical properties of paddy soils. Medium intensity puddling was shown to be the proper tillage practice for paddy fields with silty clay soil.