Effect of Cooking and Processing on CIPC Residue Concentrations in Potatoes and Processed Potato Products

Abstract

Residue concentrations of the sprout suppressant chlorpropham (or CIPC) were determined in raw and cooked potatoes and processed potato products, 48 h after CIPC aerosol treatment and after 30 days of subsequent storage at 4 or 12 °C. In the raw (uncooked) tuber, 48 h after CIPC treatment, the CIPC residue in the peel was 4.7 mg kg-1, while in the peeled tuber it was 0.1 mg kg-1. Boiling resulted in a decrease in residue concentration in the peel, but no significant differences in the residue concentration of the peeled tuber were observed. Pressure cooking resulted in a significantly increased residue concentration in the peel, but no significant change in the peeled tuber, whereas microwave cooking also did not increase the residue concentration in the peel significantly compared with that in raw tubers. Also the trend towards increases in residue concentration in microwave-cooked peeled tubers was not significant. The CIPC residue concentration detected in peeled tubers was 0.4–0.7 mg kg-1 after boiling, 0.4–1.5 mg kg-1 after pressure cooking and 0.4–3.8 mg kg-1 after microwave cooking. The highest values were always found for tubers stored for 30 days at 4 °C. Processed products such as crisps, French fries, dehydrated sliced potatoes and starch contained different concentrations of CIPC residue, which was also detected in the cooking water and frying oil. The highest residue concentrations detected were 0.7, 4.7, 1.3 and 0.2 mg kg-1 in crisps, French fries, dehydrated sliced potatoes and starch, respectively. The highest CIPC residue concentration observed in raw potatoes was much lower than the maximum residue level of 10 mg kg-1 prescribed by the European Union.