Effect of Acetylene on the γ-Ray Crosslinking Polymerization of Various Kinds of Acrylic Monomers

Abstract

Abstract The γ-radiation-induced crosslinking polymerization of methyl methacrylate (MMA), methacrylic acid (MAA), 2-hydroxyethyl methacrylate (HEMA), methyl acrylate (MA), and acrylic acid (AA) was carried out in bulk. The polymerization rates of AA and HEMA were much larger than those of other monomers. Acetylene had no influence on the polymerization rate in the initial stage, and the rate was dependent only on the kinds of monomers. In the absence of acetylene, gelation took place in PMA, PAA, and PHEMA obtained at complete conversion, but not in PMMA and PMAA. By the addition of acetylene, complete gelation of PMMA was observed, but no gel formation was observed for PMAA. Volume and weight swelling ratios were measured for PMA, PAA, PHEMA, and PMMA with complete gelation. It was found that by the addition of acetylene the molar concentration of crosslinks increased as much as about twice for PMA and PHEMA, and over about one hundred times for PMMA AND PAA. The relation between volume Sv and weight swelling ratio Sw was studied theoretically. Sv was expressed by the the equation, Sv = (pp /p+)Sw+ (1 -pp/ps), as a function of Sw and the densities of pure polymer (pp) and solvent (ps) in swollen polymer.