Dual-Fortified Lentil Products-A Sustainable New Approach to Provide Additional Bioavailable Iron and Zinc in Humans.

Abstract

ABSTRACTBackgroundIron (Fe) and zinc (Zn) deficiencies are global health problems affecting 20% and 33% of the world's population, respectively. Lentil (Lens culinaris Medik.), part of the staple food supply in many countries, can be a potential vehicle for Fe and Zn fortification.ObjectiveWe developed a dual-fortification protocol to fortify 3 milled lentil product types (LPTs) [red-football (RF), red-split (RS), and yellow-split (YS)], with NaFeEDTA and ZnSO4.H2O to increase the bioavailable content of Fe and Zn.MethodsAppropriate Fe and Zn doses were determined to fortify lentils based on RDAs. Relative Fe bioavailability (RFeB%) and phytic acid (PA) content were assessed using an in vitro Caco-2 cell bioassay and PA analysis, respectively. One-factor ANOVA determined the differences in colorimetric score; concentrations of Fe, Zn, and PA; and RFeB% among samples. The least significant difference was calculated with significance level set at P < 0.05.ResultsFe and Zn concentration and RFeB% increased and PA concentration decreased significantly in dual-fortified lentils. Dual-fortified lentil samples had higher RFeB% compared with Fe-fortified (single) samples in all 3 LPTs, whereas RFeB% decreased in Zn-fortified (single) RF and YS samples by 43.4% and 36%, respectively. The RF, RS, and YS samples, fortified with 16 mg Fe and 8 mg Zn/100 g of lentils, provided 27 mg Fe and 14 mg Zn, 28 mg Fe and 13.4 mg Zn, and 29.9 mg Fe and 12.1 mg Zn, respectively. RFeB% of RF, RS, and YS lentil samples increased by 91–307%, 114–522%, and 122–520%, respectively. Again, PA concentrations of RF, RS, and YS lentils were reduced by 0.63–0.53, 0.83–0.71, and 0.96–0.79 mg/g, respectively.ConclusionsDual-fortified lentil consumption can cost-effectively provide a significant part of the daily bioavailable Fe and Zn requirements of people with these 2 globally important micronutrient deficiencies.