Dephytinization of wheat bran by fermentation with bakers' yeast, incubation with barley malt flour and autoclaving at different pH levels

Abstract

Wheat bran is an important source of dietary fiber but also contains considerable amounts of phytic acid, which is known to impair mineral absorption. The present study was conducted to investigate the phytic acid reduction in coarse and fine wheat bran by fermentation with the different levels of bakers' yeast (3, 6 and 9%) for 8 h at 30 °C, incubation with the different levels of barley malt flour (2.5, 5.0, 7.5 and 10.0%) for 8 h at pH 5.2 and 55 °C, and autoclaving at the different pH levels (pH 5.0, 4.5, 4.0 and 3.5) adjusted with acetic acid for 2 h. The phytic acid content of the wheat bran was effectively reduced by all treatments, and the phytic acid lost was in the range of 88.4–96.9%. Without addition of yeast or malt flour, or autoclaving without pH adjustment, the phytic acid content of the bran samples was reduced at most to 44.9% of the initial amounts under the investigated conditions. Increasing the concentration of yeast or malt flour or decreasing the pH towards 3.5 did not enhance the phytic acid reduction. The most reduction occurred after 2 h of yeast fermentation and malt flour incubation, and after 30 min of autoclaving, which made up 92–98% of the total phytic acid loss. Extending the treatment periods contributed nominally to further increase in the phytic acid reduction, and the rate of the phytic acid loss decreased progressively.