Defluoridation using novel chemically treated carbonized bone meal: batch and dynamic performance with scale-up studies.

Abstract

Novel defluoridating adsorbent was synthesized by chemical treatment of carbonized bone meal using aluminum sulfate and calcium oxide. Precursor for chemical treatment was prepared by partial carbonization of raw bone meal at 550°C for 4h. Maximum fluoride removal capacity was 150mg/g when carbonized bone meal (100g/L) was treated with aluminum sulfate (500g/L) and calcium oxide (15g/L). Morphological analysis revealed formation of a coating layer consisting of aluminum compounds on the precursor surface. This was verified by stretching frequency of aluminum hydroxide (602cm-1) in the infrared spectra. Presence of hydroxylapatite (2θ= 30° and 2θ= 24°) and aluminum mineral phases (2θ= 44°) in the adsorbent were identified from the X-ray diffractograms. Adsorption capacity decreased from 150mg/g (30°C) to 120mg/g (50°C) indicating exothermic adsorption. Adsorption experiments under batch kinetic mode were simulated using shrinking core model. Effective fluoride diffusivity in the adsorbent and the mass transfer coefficient were estimated as 5.8 × 10-12m2/s and 9 × 10-4m/s, respectively. Desorption was maximum at basic pH and desorption efficiency was decreased by 31% after third cycle. Dynamic filtration with artificially fluoride-spiked solution showed that the empty bed contact time for a packed column with equal weight of carbonized and chemically treated adsorbent was 4.7min and number of bed volumes treated (till WHO limit of 1.5mg/L) was 340 for a column of 3-cm diameter and 18-cm length. The system was successfully tested using contaminated groundwater from an affected area. Fixed-bed column experiments were simulated from the first principles using convective pore diffusion-adsorption model for both synthetic solution and contaminated groundwater. Axial dispersion coefficient was found to be one order of magnitude less than the pore diffusivity indicating dominance of fluoride diffusion within porous network of adsorbent. The developed adsorbent exhibited antibacterial property as well.