Concentration-dependence of aniline-induced methemoglobinemia in dogs: A derivation of an acute reference concentration

Abstract

Four male Beagle dogs per group were head-only exposed to aniline vapor in concentrations ranging from 15.8 to 493.6 mg/m 3. Each exposure session was for 4 h. Additionally, one group of dogs was both head-only and whole-body exposed to approximately 241 mg/m 3 to better appreciate the contribution of dermal uptake on methemoglobin (MetHb) induction. The exposure paradigm chosen was comparable to a dose-escalation type of study, however, providing adequate recovery periods between each exposure session to exclude ‘carry-over’ effects from one exposure session to another. This was verified by the determination of standard hematology endpoints before and after each exposure session. The time- and concentration-dependence of MetHb was analyzed as the key endpoint. The results of this study show that MetHb was maximal around the end of the 4 h exposure period. Significantly increased MetHb was observed at concentrations equal and above 30.3 mg/m 3 at a duration of exposure of at least 60 min. The extent of MetHb formation observed in some hyperventilating dogs suggests that the dosing-rate is important for the outcome of test. Whole body exposed dogs displayed markedly higher MetHb values when compared to head-only exposed dogs. Taking into account the entire concentration–time-effect relationship 23.6 and 20.6 mg/m 3 were estimated to be the threshold concentrations to cause 0.8% MetHb following a 4 and 8 h exposure period, respectively. The C n × t analysis of MetHb formation is consistent with a concentration-dependent restoration kinetics of MetHb suggesting that results from high level exposures cannot readily be extrapolated to low-level exposures. In summary, this study demonstrates that for aniline, an agent known to be bioactivated by a hepatic first-pass metabolism, the rate of delivery and uptake appears to be decisive for the extent of MetHb formation. Carry-over effects related to erythrotoxicity or Heinz body formation were not observed at any exposure level.