Comparison of wheat gluten and spray-dried animal plasma in diets for nursery pigs1,2

Abstract

Five experiments were conducted to determine the effects of different wheat gluten (WG) sources (Source 1 = enzymatically hydrolyzed, Source 2 = nonmodified ring-dried, Source 3 = spray-dried, and Source 4 = flash-dried) on growth performance of nursery pigs compared with soybean meal (SBM), spray-dried animal plasma (SDAP), or other specialty protein sources. In Exp. 1, pigs (n = 220, initially 6.1 +/- 2.5 kg) were fed a control diet containing (as-fed basis) 6% SDAP or WG Source 1 or 2. The WG and l-lysine*HCl replaced 50 or 100% of the SDAP. From d 0 to 21, increasing WG (either source) decreased ADG and ADFI (linear, P < 0.01), but improved (linear, P < 0.02) G:F. In Exp. 2, pigs (n = 252, initially 6.2 +/- 3.0 kg) were fed a negative control diet containing no SDAP or WG, diets containing (as-fed basis) 9% WG Source 1 or 5% SDAP, or combinations of WG and SDAP where WG and l-lysine*HCl replaced 25, 50, or 75% of SDAP. From d 0 to 14, pigs fed increasing WG had decreased ADG (linear, P < 0.05). In Exp. 3, pigs (n = 240, initially 7.0 +/- 2.5 kg) were fed a negative control diet, a diet containing (as-fed basis) either 3, 6, 9, or 12% WG Source 3, or a positive control diet containing 5% SDAP. The diets containing 9% WG and 5% SDAP had the same amount of SBM. From d 0 to 7, pigs fed 5% SDAP had greater (P < 0.04) ADG than pigs fed the diet containing 9% WG. From d 0 to 14, increasing WG had no effect on ADG, ADFI, or G:F. In Exp. 4, pigs (n = 200, initially 6.0 +/- 2.4 kg) were fed a negative control diet, the control diet with (as-fed basis) 4.5 or 9.0% WG Source 1, or the control diet with 2.5 or 5.0% SDAP. Diets containing WG and SDAP had similar SBM levels. From d 0 to 7 and 0 to 14, increasing SDAP tended to improve (linear, P < 0.06) ADG, but increasing WG had no effect. In Exp. 5, 170 barrows and gilts (initially 7.5 +/- 2.8 kg) were used to determine the effects of WG Source 1 and 4 compared with select Menhaden fish meal or spray-dried blood cells and a negative control diet (SBM) on the growth performance of nursery pigs from d 5 to 26 postweaning (d 0 to 21 of experiment). No differences were found in ADG or G:F, but pigs fed the diet containing (as-fed basis) 2.5% spray-dried blood cells had greater ADFI than pigs fed the negative control from d 0 to 21. Wheat gluten source had no effect on ADG, ADFI, or G:F. The results of these studies suggest that increasing WG in diets fed immediately after weaning did not improve growth performance relative to SBM or SDAP.