Comparative Usability Study of a Novel Auto-Injector and an Intranasal System for Naloxone Delivery.

Abstract

IntroductionThe standard of care for reversal of opioid-induced respiratory depression associated with opioid overdose is injectable naloxone. This study compared the usability of two naloxone delivery devices, a naloxone auto-injector (NAI) and a naloxone intranasal delivery system (NXN), in the administration of naloxone during a simulated opioid overdose emergency. NAI (EVZIO®; kaleo, Inc., Richmond, VA, USA) is a Food and Drug Administration approved single-use pre-filled auto-injector containing 0.4 mg of naloxone.MethodsStudy participants were randomly assigned to administer naloxone using NAI and NXN, sequentially. The primary endpoint was successful administration of a simulated dose of naloxone into a mannequin during a simulated opioid emergency, both before and after receiving training. Secondary endpoints included using the NAI or NXN in accordance with the instructions-for-use and the comparative measurement of successful completion time of administration for both NAI and NXN.ResultsA total of 42 healthy participants aged 18–65 years were enrolled in the study. The proportion of participants able to successfully administer a simulated dose of naloxone was significantly greater for NAI compared to NXN both before (90.5% vs. 0.0%, respectively, P < 0.0001) and after (100% vs. 57.1%, respectively, P < 0.0001) participant training. The proportion of participants able to administer a simulated dose of naloxone in accordance with the instructions-for-use was also significantly greater for NAI compared to NXN before (85.7% vs. 0.0%, respectively, P < 0.0001) and after (100% vs. 0.0%, respectively, P < 0.0001) participant training. The average time to task completion for administration attempt before training was 0.9 ± 0.25 min for NAI versus 6.0 ± 4.76 min for NXN and after training was 0.5 ± 0.15 min for NAI versus 2.0 ± 2.15 min for NXN.ConclusionLaypersons experienced substantially greater success administering a simulated dose of naloxone, both before and after training, using NAI versus NXN during a simulated opioid overdose emergency. No participants correctly used NXN without training.Electronic supplementary materialThe online version of this article (doi:10.1007/s40122-015-0035-9) contains supplementary material, which is available to authorized users.