Comparative analysis of performance of dual fuel (DF) and homogeneous charge compression ignition (HCCI) engines fuelled with honne oil methyl ester (HOME) and compressed natural gas (CNG)

Abstract

Experiments were conducted at different compressed natural gas energy ratio (CNGER), brake mean effective pressure (BMEP) and charge temperatures to perform the comparative analysis of homogeneous charge compression ignition (HCCI) and dual fuel (DF) engines. Compressed natural gas (CNG) was inducted along with air and diesel/honne oil methyl ester (HOME) was injected into the intake air to control the start of combustion. The engine could not run at BMEP below 2.5bar in the HCCI mode as the intake charge temperature could not be raised beyond 145°C due to system limitations and beyond a BMEP of 4bar, combustion rate became very high and very careful control over the charge temperature and CNG flow rate was needed. In DF mode the liquid fuel was injected into the cylinder and CNG was inducted along the intake air. Brake thermal efficiency (BTE) of compressed natural gas diesel homogeneous charge compression ignition (CNGDHCCI) and compressed natural gas biodiesel homogeneous charge compression ignition (CNGBHCCI) as well as the compressed natural gas diesel dual fuel (CNGDDF) and compressed natural gas biodiesel dual fuel (CNGBDF) modes are lower than that of neat diesel powered compression ignition (CI) mode of engine operation. However, the BTE of CNGDHCCI and CNGBHCCI is always better than that of CNGDDF and CNGBDF modes. Nitrogen oxide (NOx) and smoke emission drastically reduced in HCCI mode of engine operation but carbon monoxide (CO) and hydrocarbon (HC) emissions are higher.