Chemical Reaction-Driven Spreading of an Organic Extractant on the Gas-Water Interface: Insight into the Controllable Formation of a Gas Bubble-Supported Organic Extractant Liquid Membrane.

Abstract

The extraction and recovery of low-concentration valuable metals from various complex aqueous solutions or industrial waste waters have attracted extensive interests in recent years. In our previous works, we suggested a novel technique called bubbling organic liquid membrane extraction by spreading and covering an organic extractant with extremely small volume on the surface of gas bubbles to form a layer of the gas bubble-supported organic liquid membrane for selective extraction and enrichment of low-concentration targets from dilute aqueous solutions. It was found that for successfully performing the bubbling organic liquid membrane extraction, a prerequisite is knowing how to control the formation of a stable organic liquid membrane covered on the surface of gas bubbles. However, once the organic extractant starts to spread on the surface of gas bubbles, the extraction chemical reaction at the interface between the organic extractant liquid membrane and the rare-earth aqueous solution will occur. In the present work, the spreading behavior of the organic extractant P507 on the surface of rare-earth aqueous solutions was investigated and was compared with the behaviors on the surface of deionized water. It was revealed that the spreading of the organic extractant P507 on the surface of aqueous solutions containing rare-earth ions was accelerated because of the occurrence of the chemical reactions at the gas-water interface. The difference in the spreading rate of organic extractant P507 liquid droplets on the surface of deionized water and on that of Er(III) aqueous solutions with an increase in the P507 concentration, the saponification degrees of the P507 extractant, and the preloading amount of Er(III) in the P507 extractant revealed that the chemical reaction at the interface between the spreading P507 thin liquid membrane and the Er(III) aqueous solution would result in the Marangoni convection along the interface, which is in favor of overcoming the resistance from the viscous force when the surface tension gradient replaces gravity as a dominant driving force for the spreading. The present work provides an experimental foundation toward understanding the effect of the interfacial chemical reaction on the spreading behavior of an organic oil droplet on the gas-water interface. It is beneficial for the development of our suggested new technique of bubbling organic liquid membrane extraction and to achieve a controllable generation of a stable gas bubble-supported organic liquid membrane for performing solvent extraction at large aqueous-to-oil phase ratios.