Characterizing non-methane volatile organic compounds emissions from a swine concentrated animal feeding operation

Abstract

Emissions of non-methane volatile organic compounds (NMVOCs) were determined from a swine concentrated animal feeding operation (CAFO) in North Carolina. NMVOCs were measured in air samples collected in SUMMA and fused-silica lined (FSL) canisters and were analyzed using a gas chromatography flame ionization detection (GCeFID) system. Measurements were made from both an anaerobic lagoon and barn in each of the four seasonal sampling periods during the period June 2007 through April 2008. In each sampling period, nine to eleven canister samples were taken from both the anaerobic lagoon and barn over a minimum of four different days during a period of w1 week. Measurements of meteorological and physiochemical parameters were also made during the sampling period. In lagoon samples, six NMVOCs were identified that had significantly larger emissions in comparison to other NMVOCs. This included three alcohols (ethanol, 2-ethyl-1-hexanol, and methanol), two ketones (acetone and methyl ethyl ketone (MEK)) and an aldehyde (acetaldehyde). The overall average fluxes for these NMVOCs, ranged from 0.18 m gm �2 min � 1 for 2-ethyl-1-hexanol to 2.11 m gm �2 min �1 for acetone, with seasonal fluxes highest in the summer for four (acetone, acetaldehyde, 2-ethyl-1-hexanol and MEK) of the six compounds In barn samples, there were six NMVOCs that had significantly larger concentrations and emissions in comparison to other NMVOCs. These consisted of two alcohols (methanol and ethanol), an aldehyde (acetaldehyde), two ketones (acetone and 2,3-butanedione), and a phenol (4-methylphenol). Overall average barn concentration ranged from 2.87 ppb for 4-methylphenol to 16.12 ppb for ethanol. Overall average normalized barn emission rates ranged from 0.10 g day �1 AU �1 (1 AU (animal unit) ¼ 500 kg of live animal weight) for acetaldehyde to 0.45 g day �1 AU �1 for ethanol. The NMVOCs, 4methylphenol and 2,3-butanedione, which have low odor thresholds (odor thresholds ¼ 1.86 ppb and 0.068e0.264 ppb for 4-methylphenol, and ¼ 4.37 ppb and 1.42e7.39 ppb for 2-3-butanedione) and an offensive odor were identified in canister samples. Both 4-methylphenol and 2,3-butanedione barn concentrations exceeded their odor thresholds frequently. HAPs were identified in lagoon samples (methanol, acetaldehyde and MEK) and barn samples (methanol, acetaldehyde and 4-methylphenol) that were also classified as NMVOCs with significantly larger lagoon and barn emissions in comparison with other NMVOCs. The overall average lagoon fluxes and overall average normalized barn emissions for NMVOCs reported in this paper were used to estimate their North Carolina swine CAFO emissions. Of the NMVOCs, ethanol was estimated to have the largest North Carolina swine CAFO emission at 206,367 kg yr �1 . The barns were found to have higher emissions than the lagoons for all NMVOCs, contributing between 68.6 to w100% of individual compounds estimated North Carolina swine CAFO emissions.